Trimble SPS610 Total Station
With cable-free operation in Autolock, Servo or Robotic modes, the Trimble SPS610 Total Station is the straightforward solution for site measurement, stakeout, and reflectorless measurement needs. This versatility provides the contractor with an easy-to-set up, easy-to-use positioning sensor that increases productivity in the field.
The SPS610 Total Station takes very little setup time and requires only two known points to establish position and orientation. Not only does the SPS610 Total Station provide superior tracking, but the single-person robotic operation increases cost savings and productivity.
Trimble SPS610 Key Features:
- DR Standard reflectorless measurement capability allows high accuracy measurement to vertical surfaces and inaccessible points without the risk and delay of a sending a person to dangerous locations.
- Trimble MagDrive™ servos provide unmatched instrument turning and tracking speeds
- Trimble SurePoint™ technology auto-corrects instrument pointing formislevelment so you’ll always capture accurate 3D information
- Unique Trimble MultiTrack™ technology allows operation with conventional prisms or active targets
- Servo controls and telescope focus are located on the instrument side panel, providing convenient, ergonomic, one handed operation
- Long battery life allows over six hours robotic operation on one smart lithium ion battery
Precise Measurement
The Trimble SPS610 Total Station is a 5” instrument in both the horizontal and vertical angles. Available in Servo, Autolock, or Robotic models, it offers DR Standard for precise prism and reflectorless distance measurement and an Autolock and Robotic range of 300 meters in any direction from the instrument.
Trimble Multitrack Technology
The SPS610 Total Station allows you to assign a unique target identifier to the target being used providing you with the confidence that the instrument will lock and track only the correct target. All other reflective objects and targets on the jobsite are ignored, guaranteeing no operation interruptions or incorrect measurements.
Market-leading Trimble Technology
Exclusive Trimble MagDrive™ servos provide quiet, effortless operation and the fastest, most responsive and accurate tracking available today. Unique Trimble SurePoint™ technology autocorrects instrument pointing for mislevelment and internal calibrations in real time. You will never again record information only to find that your instrument wasn’t level.
Tracking the target at short range or in areas where the rate of angular change is high always creates a challenge. Having fast servos allows the instrument to track more reliably. The Trimble SPS610 Total Station uses patented Trimble MagDrive fourth generation servo technology, which uses electro-magnets to eliminate direct drive and friction from the servo system. Combined with the USB communications network for the fastest command response time, the system delivers the fastest tracking, fastest turning, most responsive instrument available.
Total stations depend on being level to deliver accurate results. When an instrument is knocked, buffeted by wind, or subjected to ground vibration, its level is affected. Dual-axis compensation corrects the angle measurement system for mislevelment, but doesn’t change the instrument's pointing to account for the associated errors. Patented Trimble SurePoint technology not only corrects the angles for mislevelment, it also continually adjusts the instrument’s pointing to deliver the most accurate automated positioning available.
Trimble SPS610 Total Station Specifications:
Angle Measurement
Horizontal Accuracy
(Standard deviation based on DIN 18723). . . . . . . . . . . . .5" (1.5 mgon)
Vertical Accuracy
(Standard deviation based on DIN 18723). . . . . . . . . . . . .5" (1.5 mgon)
Angle Reading (least count)
Standard. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1" (0.1 mgon)
Tracking. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1" (0.1 mgon)
Automatic level compensator. . . . . . . . . . . . . . . . Dual-axis compensator ±6' (±100 mgon)
Distance Measurement
Accuracy (Standard Deviation) Prism Mode
Standard. . . . . . . . . . . . . . . . . . . .± (2 mm + 2 ppm) ± (0.01 ft + 2 ppm)
Tracking. . . . . . . . . . . . . . . . . . .± (5 mm + 2 ppm) ± (0.032 ft + 2 ppm)
Dynamic Measurement Capability
Synchronized angle and distance measurements. . . . . . . . . . . . . . . . No
Maximized position update rate. . . . . . . . . . . . . . . . . . . . . . . . . . 2.5 Hz
3D Positioning Accuracy Note: 3D positioning accuracy is based on the following parameters:
Angle accuracy (horizontal and vertical position accuracies vary with range measured and vertical angle)
Distance measurement accuracy (ppm error causes accuracy to vary with range measured)
Tracker lock on accuracy
Static or moving target
DR Reflectorless Mode
Standard measurement. . . . . . . .± (3 mm + 2 ppm) ± (0.01 ft + 2 ppm)
Tracking . . . . . . . . . . . . . . . . .± (10 mm + 2 ppm) ± (0.032 ft + 2 ppm)
Measuring Time - Prism mode
Standard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 s
Tracking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .0.4 s
Measuring Time - DR Mode
Standard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-15 s
Tracking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .0.4 s
Range (under clear conditions1,2)
Prism Mode
1 prism. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3,000 m (9,800 ft)
1 prism Long Range mode. . . . . . . . . . . 5,000 m (16,400 ft) max range
3 prism. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5,000 m (16,400 ft)
3 prism Long Range mode. . . . . . . . . . . 7,000 m (23,000 ft) max range
Shortest possible range. . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.5 m (4.9 ft)
DR Mode
Kodak Gray Card (18% reflective)3. . . . . . . . . . . . . . . .>120 m (394 ft)
Kodak Gray Card (90% reflective)3. . . . . . . . . . . . . . . . .>150 m (492 ft)
Concrete. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80-150 m (262-492 ft)
Wood construction. . . . . . . . . . . . . . . . . . . . . . . . 80-180 m (262-590 ft)
Metal construction. . . . . . . . . . . . . . . . . . . . . . . . 80-120 m (262-394 ft)
Light rock. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80-120 m (262-394 ft)
Dark rock. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60-80 m (197-262 ft)
Reflective foil 20 mm. . . . . . . . . . . . . . . . . . . . . . . . . . . 600 m (1,968 ft)
Reflective foil 60 mm. . . . . . . . . . . . . . . . . . . . . . . . . . 1200 m (3,937 ft)
Shortest possible range. . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.5 m (4.9 ft)
Light source
Laserdiode 660 nm. . . . . . . . . . . . . . . . . . . . . .Laser class 1 in Prism mode
Laser class 2 in DR mode
Laser pointer coaxial (standard). . . . . . . . . . . . . . . . . . . . . . . Laser class 2
Beam divergence - Prism mode
Horizontal. . . . . . . . . . . . . . . . . . . . . . . . . . . 4 cm/100 m (0.13 ft/328 ft)
Vertical. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 cm/100 m (0.13 ft/328 ft)
Beam divergence - DR mode
Horizontal. . . . . . . . . . . . . . . . . . . . . . . . . . . 2 cm/50 m (0.066 ft/164 ft)
Vertical. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 cm/50 m (0.066 ft/164 ft)
Atmospheric correction. . . . . . . . . . . . .130 ppm to 160 ppm continuous
Leveling
Circular level in Tribrach. . . . . . . . . . . . . . . . . . . . . .8'/2 mm (8'/0.007 ft)
Electronic 2-axis level in the LC- display . . . . . . . . . . . . 0.3" (0.1 mgon)
Servo system. . . . . . . . . . . . . . .MagDrive servo technology, integrated servo/angle sensor electromagnetic direct drive
Rotation speed. . . . . . . . . . . . . . . . . . . . .115 degrees/sec (128 gon/sec)
Positioning speed 180 degrees (200 gon). . . . . . . . . . . . . . . . . . .3.2 sec
Clamps and slow motions . . . . . . . . . . . . . . . . . MagDrive servo-driven endless fine adjustment
Centering
Centering system. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Trimble 3-pin
Optical plummet. . . . . . . . . . . . . . . . . . . . . . . .Alidade optical plummet
Magnification/shortest focusing distance . . . . . . . . .2.3×/0.5 m–infinity (1.6 ft–infinity)
Telescope
Magnification. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30×
Aperture. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40 mm (1.57 in)
Field of view at 100 m (328 ft). . . . . . . . . . . . . . . . . . . . . . .2.6 m (8.5 ft)
Shortest focusing distance. . . . . . . . . . . . . . . . . .1.5 m (4.92 ft)–infinity
Illuminated crosshair. . . . . . . . . . . . . . . . . . . . . . . . . . Variable (10 steps)
Trimble Tracklight®built in. . . . . . . . . . . . . . . . . . . . . . . . . . . .Standard
Operating temperature. . . . . . . . . .–20 ºC to +50 ºC (–4 ºF to +122 ºF)
Dust and water proofing. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .IP55
Focus type . . . . . . . . . . . . . . . . . . . . . . . . . . Servo assisted on side cover
Power supply
Removable Internal
battery. . . . . . . . . . . Rechargeable Lithium-ion battery 11.1 V, 4.4 Ah
Operating time4,5
One internal battery. . . . . . . . . . . . . . . . . . . . . . Approximately 6 hours
Three batteries in multi-battery adapter. . . . Approximately 18 hours
Trimble CU Robotic holder
with one internal battery. . . . . . . . . . . . . . . . Approximately 12 hour
Weight
Instrument (Servo/Autolock. . . . . . . . . . . . . . . . . . . . .5.15 kg (11.35 lb)
Instrument (Robotic). . . . . . . . . . . . . . . . . . . . . . . . . . .5.25 kg (11.57 lb)
Trimble CU controller . . . . . . . . . . . . . . . . . . . . . . . . . . . .0.4 kg (0.88 lb)
Tribrach. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .0.7 kg (1.54 lb)
Internal battery. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .0.35 kg (0.77 lb)
Trunnion axis height. . . . . . . . . . . . . . . . . . . . . . . . . . . . 196 mm (7.71 in)
Handle . . . . . . . . . . . Detachable and eccentric for unrestricted sighting
roboTic meaSuremenT
Range
Robotic. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .300 m (984 ft)
Autolock. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .300 m (984 ft)
Shortest search distance. . . . . . . . . . . . . . . . . . . . . . . . . . . .0.2 m (.65 ft)
Autolock pointing precision at 200 m (656 ft). . . . . . . <2 mm (0.007 ft)(Standard deviation)
Angle reading (least count)
Standard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1" (0.1 mgon)
Tracking. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1" (0.1 mgon)
Averaged observations. . . . . . . . . . . . . . . . . . . . . . . . . 0.1" (0.01 mgon)
Type of radio internal/external. . . . . . . . .2.4 GHz frequency-hopping, spread-spectrum radios
Search time (typical). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2–10 s
Search area . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .360 degrees (400 gon) or defined horizontal and vertical search window
Trimble Recon Data Collector
The new-generation Trimble® Recon®
handheld is as tough as ever...with an
IP67 rating, it’s impervious to water and
dust. And inside the rugged casing, it’s
packed with connectivity options.
As well as non-volatile memory, and an
industry-standard, open operating
system, you have built-in Bluetooth® and
wireless LAN. With all of this, the Trimble
Recon handheld is simply the
best-connected, lightweight and
ultra-rugged field computer available.
The Trimble Recon handheld features a
high-performance 400 MHz processor, an
improved screen that’s readable in direct
sunlight, and a built-in microphone. The
system provides two CompactFlash (CF)
slots, letting you add GPS cards, barcode
scanners and other devices—or add a
memory card if you want to take
additional data into the field.
Connectivity Options
Bluetooth lets you connect to mobile
peripherals without cables, and wireless
LAN gives you access to local area networks,
email and the Internet. You can use
Bluetooth to connect wirelessly to
other devices such as a laser rangefinder,
or if you need to navigate or map assets
for your GIS, the Trimble Recon handheld
connects seamlessly with Trimble’s
GPS Pathfinder® receivers.
If you are within range of a Wi-Fi network,
the built-in wireless LAN in your Trimble
Recon handheld makes it very easy to send
and receive data—as soon as you arrive at
a Wi-Fi hotspot, such as your office or work
depot, you can quickly and securely transfer
large amounts of data into the network.
Cellular connectivity can be added to the
Trimble Recon handheld via the TDL 3G
cellular modem. Connecting via wireless
LAN or Bluetooth, the TDL 3G provides
continuous network/internet access to
real-time map data, web-based services,
and live update of field information.
Industry-standard software
The Trimble Recon handheld is powered by
the Windows Mobile® version 6 operating
system—so you can choose the software
that matches your workflow, whether it's
off-the-shelf or purpose-built. And because
all your data and applications reside in
persistent storage, they are secure even in
the event of power loss.
Rugged and reliable
Designed for the realities of mobile GIS
field work, the Trimble Recon is a rugged
and reliable handheld which connects
seamlessly with Trimble GPS receivers.
Mobile technology is changing fast, but the
Trimble Recon handheld is designed with
the future in mind—its open operating
system, expandable storage and flexible
connectivity deliver all you need, and
more, in the most rugged, reliable
solution available.
Features
- Ultra-rugged and lightweight
- Integrated wireless connectivity
(Bluetooth and wireless LAN)
- GPS functionality easily added
- Windows Mobile version 6
operating system
Specifications:
| Standard features |
• Windows Mobile version 6
operating system
• 1 x Type I and 1 x Type I/II CompactFlash (CF) slots for memory
expansion
and the addition of accessories
• Outdoor color display
• Rugged and waterproof design
• Integrated speaker and microphone
• 400 MHz Intel PXA255 XScale processor
• 256 MB non-volatile Flash data storage
• Integrated Bluetooth1 wireless technology for connectivity to other
device
• Integrated 802.11g wireless LAN for local network connectivity
Software
• Microsoft® ActiveSync®
, Microsoft Office Mobile (Word Mobile, Excel
Mobile, OneNote Mobile, PowerPoint Mobile), Internet Explorer Mobile,
File Explorer, Windows Live® Messenger, Windows Media Player, Pictures
& Videos, Outlook Mobile, Contacts, Calendar, Tasks, Calculator
• Bluetooth File Transfer
• Transcriber (handwriting recognition) |
| Technical
specifications |
| Physical |
| Size |
16.5 cm × 9.5 cm × 4.5 cm (6.5
in × 3.75 in × 1.75 in) |
| Weight |
0.49 kg (17 oz) with battery
module |
| Processor |
400 MHz Intel PXA255 XScale CPU |
| Memory |
Nonvolatile NAND Flash 256 MB
(~31 MB reserved) |
| Battery |
Internal 3800 mAh NiMH,
rechargeable in unit |
| Environmental |
| Operating temperature |
–30 °C to +60 °C (–22 °F to +140
°F) |
| Storage temperature |
–40 °C to +70 °C (–40 °F to +158
°F) |
| Humidity |
MIL-STD-810F, Method 507.4 |
| Sand and dust |
IP67, MIL-STD-810F, Method
510.4, Procedures I and II |
| Water. |
IP67, sealed against accidental
immersion (1 m for 30 min)
MIL-STD-810F, Method 512.4, Procedure I |
| Drop. |
1.22 m (4 ft), MIL-STD-810F,
Method 516.5, Procedure IV
26 drops from 1.22 m (4 ft) onto plywood over concrete
6 additional drops at -30 °C (-22 °F)
6 additional drops at 60 °C (140 °F) |
| Vibration |
Vibration resistant,
MIL-STD-810F, Method 514.5 |
| Altitude |
MIL-STD-810F, Method 500.4,
Procedures I, II & III
15,000 ft at 23 °C (73 °F) |
| Input/output |
| Expansion |
1 × Type I and 1 × Type I/II CF
slot
CF-Cap seal protects from rain, wind, and dust |
| Display |
240 × 320 pixel (¼ VGA) color
TFT with LED front light |
| Interface |
TFT touch screen, 10 hardware
control keys
Soft Input Panel (SIP) virtual keyboard and Transcriber software
Audio system events, warnings, and notifications |
| Communications |
Bluetooth, 802.11g wireless LAN
DE9 (M) RS-232 serial port, USB-slave port |
|
